3A-C fed runablity issues
-
- Highest Ranking Member
- Posts: 826
- Joined: Mon Oct 27, 2008 5:42 pm
- My tercel:: The General, 85 SR5 w/ Sunroof,Olive Drab paint, Black Interior, custom steel bumpers, Barto BC lift, 1.67L BUILT 3AC w/ Weber Carb. 346,000 miles and counting since restoration
- Location: Seattle WA
- Contact:
3A-C fed runablity issues
Rhonda sat for 7 or 8 years with a broken main pulley. We were able to get her started and over to my shop with a handful of driving issues.
I completed the 175k service, timing belt, waterpump ect as well as replaced the clutch/pressureplate and a number of gaskets. I also dumped out the old gas and flushed the fuel system despite her being able to drive on it.
Rhonda fires right up with factory choke working fine. Warms to running temp with no issues. She'll run from 1k to 3k rpms with no issues. Once loaded in gear or higher rpms are attempted, she falls flat.
I've checked the the vacuum lines for propper placement and leaks, adjusted the timing to proper spec and checked for adequate fuel pressure. All are good. I've gone through the FSM and run though the trouble shooting and haven't come up with a reasonable diagnosis. Floatbowl stays at a reasonable level but I'm concerned the 2ndary jet system on the carb isn't running correctly. Before I dig into the carb, I figured I'd post here since I'm wasting time and a bit stumped.
Short video for reference.
https://youtu.be/P6eGQocBMl0
Any thoughts?
You do not have the required permissions to view the files attached to this post.
Vintage and Classic Toyota; Have you loved your Toyota today?
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody
- Mark
- Highest Ranking Member
- Posts: 886
- Joined: Mon Apr 22, 2013 9:49 pm
- My tercel:: 1984 Automatic, 1981 sedan
- Location: Victoria, B.C.
Re: 3A-C fed runablity issues
Does the distributor centrifugal advance work? With the vacuum hose(s) disconnected/plugged, rev the engine and make sure the timing advances.
-
- Highest Ranking Member
- Posts: 2121
- Joined: Thu Aug 04, 2005 11:38 am
- My tercel:: 87 tercel 4x4 wagon w/reringed engine, 83 tercel 4x4 wagon w/salvaged engine and 4.1 Diff's
- Location: seabeck, washington, USA
Re: 3A-C fed runablity issues
Carb rebuild, it’s always the carb
Love those Tercell 4x4 wagons but they sure suffer from road noise.
-
- Highest Ranking Member
- Posts: 826
- Joined: Mon Oct 27, 2008 5:42 pm
- My tercel:: The General, 85 SR5 w/ Sunroof,Olive Drab paint, Black Interior, custom steel bumpers, Barto BC lift, 1.67L BUILT 3AC w/ Weber Carb. 346,000 miles and counting since restoration
- Location: Seattle WA
- Contact:
Re: 3A-C fed runablity issues
Distributor advance is working fine.
Vintage and Classic Toyota; Have you loved your Toyota today?
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody
- ALiveSR5
- Top Notch Member
- Posts: 164
- Joined: Fri Sep 18, 2020 7:58 pm
- My tercel:: Was a stock 1985, SR5, 4WD, 6-speed manual, Wagon.
- Location: Pennsylvania USA
Re: 3A-C fed runablity issues
I swapped an engine that had been sitting for awhile, into mine, and experienced the same kind of issue. Turned out that the stock carb jets were clogged by varnish or gunk from sitting. Cleaned out the jets and it has run fine for over 25 years.SynthDesign wrote: ↑Wed Feb 03, 2021 8:57 pm Before I dig into the carb, I figured I'd post here since I'm wasting time and a bit stumped.
Any thoughts?
Hope that helps.
No other vehicle that I have ever owned had a heart and soul like my 1985 Tercel SR5 4WD Wagon.
~
Great minds may think alike but it is the doers who see their visions become reality.
~
Great minds may think alike but it is the doers who see their visions become reality.
-
- Top Notch Member
- Posts: 115
- Joined: Thu Oct 20, 2011 10:13 pm
- My tercel:: 85 toy tercel 2wd wagon (formerly a 4wd automatic)
- Location: Fresno, CA
- Contact:
Re: 3A-C fed runablity issues
Any chance the exhaust is constipated? A plugged up cat can cause a big loss of power under load. john
-
- Highest Ranking Member
- Posts: 826
- Joined: Mon Oct 27, 2008 5:42 pm
- My tercel:: The General, 85 SR5 w/ Sunroof,Olive Drab paint, Black Interior, custom steel bumpers, Barto BC lift, 1.67L BUILT 3AC w/ Weber Carb. 346,000 miles and counting since restoration
- Location: Seattle WA
- Contact:
Re: 3A-C fed runablity issues
The carb was completely filled will varnish and debris.
I scrubbed it out and got it back together in reasonable running order.
I scrubbed it out and got it back together in reasonable running order.
You do not have the required permissions to view the files attached to this post.
Vintage and Classic Toyota; Have you loved your Toyota today?
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody
- irowiki
- Highest Ranking Member
- Posts: 3463
- Joined: Tue Apr 02, 2013 10:02 am
- Location: Farmington, NM
Re: 3A-C fed runablity issues
Did it help?
Former Tercel Enthusiast (not a practical family car anymore but they still have a place in my heart)
Site administrator, if something is broken, PM me!
87 Corolla FX16, 105k
94 Jamboree RV (Ford E-350), 90k
95 Camry Wagon, 170k
97 4runner, 275k
Site administrator, if something is broken, PM me!
87 Corolla FX16, 105k
94 Jamboree RV (Ford E-350), 90k
95 Camry Wagon, 170k
97 4runner, 275k
-
- Highest Ranking Member
- Posts: 826
- Joined: Mon Oct 27, 2008 5:42 pm
- My tercel:: The General, 85 SR5 w/ Sunroof,Olive Drab paint, Black Interior, custom steel bumpers, Barto BC lift, 1.67L BUILT 3AC w/ Weber Carb. 346,000 miles and counting since restoration
- Location: Seattle WA
- Contact:
Re: 3A-C fed runablity issues
Seems to be running well enough. I think Silas has put on a maybe a thousand miles so far.
Vintage and Classic Toyota; Have you loved your Toyota today?
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody
2016 Toyota Tacoma Quad Cab LB TRD OffRoad
2005 Toyota Sienna, work van
85 Toyota Tercel SR5 4wd (The General)
85 Toyota Tercel GTS 4wd (4AGE Swap)
85 Toyota MR2 (Blu)
83 Mazda RX-7 Mariah Widebody