Do you use a load balancer when pulling engine?

Look around here for some great advice on getting the most out of your tools! Tips and tricks!
Post Reply
tercle
Top Notch Member
Posts: 197
Joined: Sat Aug 27, 2011 9:57 am
My tercel:: 1985 SR5
Location: Seattle

Do you use a load balancer when pulling engine?

Post by tercle » Wed May 09, 2018 9:33 am

I am prepping an engine swap and I was planning on renting a load balancer to adjust the engine angle.
But since a line between the engine hooks isn't parallel with the crankshaft, adjusting a load balancer is also going to shift the engine left or right.
Does it work anyway?

What is the best way to hook up a cherry picker to these engines?

Any tips are appreciated.

User avatar
splatterdog
Highest Ranking Member
Posts: 1371
Joined: Sun Mar 26, 2006 10:26 am
Location: Minnesota, USA

Re: Do you use a load balancer when pulling engine?

Post by splatterdog » Wed May 09, 2018 11:04 am

A simple chain from hook to hook will suffice. Just find the balance point in the middle, then mark the chain so it's in the same spot going back in.

Balancers can help, or get in the way. They also increase how far up you have to go. These engines are very light so manual tilting is pretty easy.

User avatar
Petros
Highest Ranking Member
Posts: 10323
Joined: Sun Jan 28, 2007 6:31 pm
My tercel:: '84 Tercel4wd w/extensive mods
Location: Arlington WA USA

Re: Do you use a load balancer when pulling engine?

Post by Petros » Wed May 09, 2018 4:05 pm

never needed a balance bar, have pulled engines on these cars too many times to count. I have used chains, but my favorite is a sturdy adjustable webbing strap (the cargo type with a hook at each end). it is easy to grab and pull on it, or slide the webbing through the lift hook to change the angle of the engine. make sure you use a 700 lb or better rated cargo strap, some of the cheap ones are only good for 250 lbs, which would lift the engine but it is not a quality item to trust to holding an engine.
'87 Tercel 4wd SR5 (current engine swap project)
'84 Tercel 4wd (daily driver, with on going mods)
'92 Mazda MPV 4wd (wife's daily driver)
'85 Tercel 4wd DLX auto(daughter's daily driver)
'01 Honda Civic (other daughter's daily driver)

Post Reply