Search found 515 matches

by jimcrazy
Sun Jun 23, 2019 3:31 am
Forum: General
Topic: Tercel name
Replies: 4
Views: 1531

Re: Tercel name

the hawk
by jimcrazy
Tue Jun 11, 2019 3:14 am
Forum: General
Topic: Parked for Months, Now Can't Find 5th/Reverse
Replies: 9
Views: 2936

Re: Parked for Months, Now Can't Find 5th/Reverse

the plunger is missing in the pic but it screws in the left side and hits on the flat side of the shifter rod,,mine was stuck in and the shifter would not spring back from 5th or reverse
by jimcrazy
Sat May 25, 2019 3:32 am
Forum: Part Numbers - OE and Aftermarket
Topic: AM Beck-Arnley Trans Front Output Seal
Replies: 9
Views: 14290

Re: AM Beck-Arnley Trans Front Output Seal

just got a bunch of stuff from rockauto yesterday the wholesaler closeout list,,,got 5 of the 223240 seals lol couple of bucks each not out much
by jimcrazy
Thu May 23, 2019 4:11 am
Forum: Tercel 4WD Repair Questions
Topic: Situation... flooded float bowl & rough unsustainable idle after new pump/dizzy/starter
Replies: 20
Views: 5017

Re: Situation... flooded float bowl & rough unsustainable idle after new pump/dizzy/starter

if you have had the top of the carb off there is a small o-ring on the primary small ventury,,if that is left off it will act like its flooding and will ldle like shit,,happened once to me found it down in the carb
by jimcrazy
Tue May 21, 2019 3:39 pm
Forum: Part Numbers - OE and Aftermarket
Topic: AM Beck-Arnley Trans Front Output Seal
Replies: 9
Views: 14290

Re: AM Beck-Arnley Trans Front Output Seal

go to manual trans and drive axle seal on rockauto
by jimcrazy
Tue May 21, 2019 4:15 am
Forum: Tercel 4WD Repair Questions
Topic: what is this thing on top of my front diff.. i think i might of bumped it.
Replies: 11
Views: 2796

Re: what is this thing on top of my front diff.. i think i might of bumped it.

checked a manual trans this morning the vent is up by the input shaft,yours being a auto the diff uses gear oil so they they put the vent there,also checked a axle the spline is larger on it 25mm in diameter
by jimcrazy
Mon May 20, 2019 3:48 pm
Forum: Tercel 4WD Repair Questions
Topic: what is this thing on top of my front diff.. i think i might of bumped it.
Replies: 11
Views: 2796

Re: what is this thing on top of my front diff.. i think i might of bumped it.

it is the vent,,make sure the cap spins free and not plugged up with dirt,,,the trans/diff will build up pressure when hot this lets it escape ,,,to much pressure in the diff will allow the seals to weep,,the seals will only stand 3 to 5 psi before leaking
by jimcrazy
Fri May 03, 2019 5:47 pm
Forum: Tercel 4WD Parts: New and Used
Topic: WTB: 4WD Transmission Mount
Replies: 5
Views: 1727

Re: WTB: 4WD Transmission Mount

all you really need is a piece of flat bar drill a hole in it and weld it to the new one
by jimcrazy
Mon Apr 29, 2019 2:31 pm
Forum: Repair Guides
Topic: Alignment
Replies: 24
Views: 7269

Re: Alignment

i have a 1" strut spacer in the front,,they had to slot the strut holes for alignment
by jimcrazy
Sun Apr 28, 2019 5:42 pm
Forum: Tercel 4WD Repair Questions
Topic: Doing my first head gasket, How does this 3a head look?
Replies: 4
Views: 1544

Re: Doing my first head gasket, How does this 3a head look?

the wire wheel scares me,,only seen it once but one of the little wires off the wheel went down the oil passages in to the oil pan and went through the screen on the oil pump and lock the oil pump and twisted the dizzy shaft off,,was a 350 chev,we found the wire locked in the oil pump gears
by jimcrazy
Thu Apr 25, 2019 6:40 pm
Forum: Tercel 4WD Repair Questions
Topic: drive shaft rebuild
Replies: 10
Views: 2671

Re: drive shaft rebuild

you have to clean up the stake marks after you get the caps out,rotary tool will do the job no problem,,,i do so many i just cut the cross with a torch then knock the caps in then clean up the stake marks then line ream them,,just did a rav and a honda pilot today,,,next one i do i will take a bunch...
by jimcrazy
Tue Apr 23, 2019 9:29 am
Forum: Tercel 4WD Repair Questions
Topic: drive shaft rebuild
Replies: 10
Views: 2671

Re: drive shaft rebuild

they are what they call staked in joints,,just a bunch of crimps hold the cap in,,
by jimcrazy
Sun Apr 21, 2019 8:26 am
Forum: Tercel 4WD Repair Questions
Topic: drive shaft rebuild
Replies: 10
Views: 2671

Re: drive shaft rebuild

better pic of the locks
by jimcrazy
Sun Apr 21, 2019 8:23 am
Forum: Tercel 4WD Repair Questions
Topic: drive shaft rebuild
Replies: 10
Views: 2671

Re: drive shaft rebuild

dlb the joints are a direct fit and they have inside locks,,the yokes are all ready machined out for them,,,i replaced all 3 and did have a small vibration at 30-40 mph,,,use a dial indicator on the drive shaft found the low side and put a 3" hose clamp with the screw part of the clamp on the l...