Search found 6984 matches

by dlb
Tue Nov 29, 2022 8:24 am
Forum: Tercel 4WD Repair Questions
Topic: JET - 2-way filter/valve??
Replies: 6
Views: 49

Re: JET - 2-way filter/valve??

You might be able to get away with using something like this, which is available at most pet stores: http://ca-en.hagen.com/Aquatic/Aeration/Accessories/A1172 It's normally used for regulating air flow in fish tanks. Looking at the test in the FSM, I'm not clear how the jet is actually supposed to w...
by dlb
Mon Nov 28, 2022 1:47 pm
Forum: Announcements
Topic: Little bit of housekeeping
Replies: 1
Views: 21

Re: Little bit of housekeeping

Long time no see indeed! Thanks for keeping things running smoothly here. I hadn't noticed the email thing, or anything else that needs attention.

Who is the feline? Latest addition to your posse?
by dlb
Sat Nov 26, 2022 11:19 am
Forum: General
Topic: carb numbers
Replies: 4
Views: 42

Re: carb numbers

thanks for the insight guys. is the FSM carb rebuild section pretty concise or is there any other steps or processes? any tips are appreciated, thanks The two times I have rebuilt Tercel carbs, I have just followed the steps that come in the carb rebuild kit. You basically just remove about 70 smal...
by dlb
Sat Nov 26, 2022 10:41 am
Forum: Tercel 4WD Repair Questions
Topic: carb fuel level still too high
Replies: 3
Views: 48

Re: carb fuel level still too high

if you replaced the seat and needle valve the level has to be reset since you changed the relationship between the float and needle valve. Thanks Peter. What do you mean by "the level has to be reset"? Should I drain the fuel out of the bowl? I assumed that would happen once the engine st...
by dlb
Thu Nov 24, 2022 9:25 pm
Forum: Tercel 4WD Repair Questions
Topic: First tercel burning oil
Replies: 2
Views: 42

Re: First tercel burning oil

Welcome to the forum, DM. Have you gone over the emissions systems yet? They seem like a lot at first glance but if you use the factory service manual (aka FSM) found on this site and go over each system on its own, it's pretty easy to make sure each system is working and they are connected properly...
by dlb
Thu Nov 24, 2022 8:54 pm
Forum: Tercel 4WD Repair Questions
Topic: carb fuel level still too high
Replies: 3
Views: 48

carb fuel level still too high

I rebuilt a carb recently because the thing barely ran, and I could see the level in the carb fuel window was too full (it was just above the top of the glass so when I shook the car I could see the level come down into sight for just a second). Tested the float and it's good, adjusted the float lev...
by dlb
Thu Nov 24, 2022 8:41 am
Forum: General
Topic: carb numbers
Replies: 4
Views: 42

Re: carb numbers

Is that on the little metal tag on the air horn? I don't think any of mine have still had that tag. When you rebuild it and remove the jets, you will see numbers stamped on the jets that indicate their size (bigger #s = bigger holes). The one I just rebuild was 159 and 109 which seems pretty common....
by dlb
Wed Nov 23, 2022 8:32 pm
Forum: Tercel 4WD Repair Questions
Topic: INT / intermittent wipers?
Replies: 3
Views: 68

Re: INT / intermittent wipers?

some of the base models only had low and high wiper modes, but most later ones also have an intermittent setting. However, someone discovered the Same years toyota Forerunners have adjustable intermittent wipers multi switch that will fit into the tercel. a good junk yard find, you will have to tri...
by dlb
Wed Nov 23, 2022 8:30 pm
Forum: General
Topic: what kind of cleaner to use during carb rebuild?
Replies: 3
Views: 98

Re: what kind of cleaner to use during carb rebuild?

I ended up not soaking anything when I rebuilt my carb last week. Just sprayed carb cleaner, wiped and brushed, and used fine soft wires to clean out the various passages. It was quite painless actually. If I was going to scrub the entire carb to make it look new, that would have been a different st...
by dlb
Wed Nov 23, 2022 6:08 pm
Forum: General
Topic: Weber carburetor questions
Replies: 12
Views: 205

Re: Weber carburetor questions

Petros wrote: Wed Nov 23, 2022 5:50 pm the PVC valve should not be connected to the EGR, they perform separate unrelated functions.
I believe they were referring to Splatterdog's EGR -> PCV conversion, for people with Weber carbs who need to remove the phenolic spacer (with its PCV port) in order to clear the hood.
by dlb
Tue Nov 22, 2022 1:40 pm
Forum: General
Topic: Weber carburetor questions
Replies: 12
Views: 205

Re: Weber carburetor questions

Cadendoo22 wrote: Tue Nov 22, 2022 12:28 pm I've never been able to figure out how to connect the Weber to the vac advance, can you elaborate?
#14 in the FAQ: viewtopic.php?t=7442
by dlb
Mon Nov 21, 2022 3:37 pm
Forum: Tercel 4WD Repair Questions
Topic: Stock vs. Weber
Replies: 17
Views: 371

Re: Stock vs. Weber

I've only had a Weber on my car and I've never had any carb problems. My gas mileage isn't great though, getting about 18 mpg but that's probably due to my 27 inch tires. 18 mpg would be terrible. 4.11 gearing should get high 20s, 3.73 gearing should get low 30s. Are you taking the size difference ...
by dlb
Mon Nov 21, 2022 9:03 am
Forum: Tercel 4WD Repair Questions
Topic: Stock vs. Weber
Replies: 17
Views: 371

Re: Stock vs. Weber

redline sends out the wrong air filter with the kits as its also aimed for the 3tc engines. theres no need for a hood scoop. the people who have cold running issues never adjusted the choke on them. you have to adjust the electric choke for the webers to run right. Not true. I and most people here ...
by dlb
Mon Nov 21, 2022 2:41 am
Forum: Cars for sale
Topic: Looking for a 4WD Tercel
Replies: 2
Views: 144

Re: Looking for a 4WD Tercel

Have you looked on craigslist and facebook marketplace? I usually find several on each when I look in the US on those platforms.
by dlb
Sun Nov 20, 2022 7:51 pm
Forum: Tercel 4WD Parts: New and Used
Topic: Carburetor Replacement
Replies: 6
Views: 127

Re: Carburetor Replacement

Here is xirdneh's (aka Rob's) carb rebuild video I mentioned, it's great:

https://www.youtube.com/watch?v=kCzFuPq ... bertwalker