Manual Transmission Removal and Re-Installation
-
- Top Notch Member
- Posts: 325
- Joined: Sat Jan 04, 2014 7:28 am
- My tercel:: 1983 SR5 4x4 with a tummy tuck and a nose job and now a pace maker!
- Location: jordache ,ca
Re: Manual Transmission Removal and Re-Installation
One question I have for this thread is you never specified what to do with the 8 turn bolt do you tighten it back up after the oil drains out or leave it loose til you done putting the new oil in then tighten it
I used to laugh at the man with a pinto , until I became a humble servicer of a tercel
-
- Highest Ranking Member
- Posts: 2121
- Joined: Thu Aug 04, 2005 11:38 am
- My tercel:: 87 tercel 4x4 wagon w/reringed engine, 83 tercel 4x4 wagon w/salvaged engine and 4.1 Diff's
- Location: seabeck, washington, USA
Re: Manual Transmission Removal and Re-Installation
leave loose until done refilling
Love those Tercell 4x4 wagons but they sure suffer from road noise.
-
- Top Notch Member
- Posts: 325
- Joined: Sat Jan 04, 2014 7:28 am
- My tercel:: 1983 SR5 4x4 with a tummy tuck and a nose job and now a pace maker!
- Location: jordache ,ca
Re: Manual Transmission Removal and Re-Installation
Thank you sir .and since I have you here ,I got this sound have had it for awhile coming from rear drivers side wheel when I apply the brakes hard.it isn't a constant noise just when I have to stop in a hurry .it sounds almost like a jake brake if you know what I mean
I used to laugh at the man with a pinto , until I became a humble servicer of a tercel
-
- Top Notch Member
- Posts: 325
- Joined: Sat Jan 04, 2014 7:28 am
- My tercel:: 1983 SR5 4x4 with a tummy tuck and a nose job and now a pace maker!
- Location: jordache ,ca
Re: Manual Transmission Removal and Re-Installation
I will start a new thread sorry
I used to laugh at the man with a pinto , until I became a humble servicer of a tercel
-
- Newbie
- Posts: 3
- Joined: Sun Oct 28, 2018 11:46 pm
- My tercel:: Toyota Corolla II
Re: Manual Transmission Removal and Re-Installation
It's a very useful observation by you. Thanks for sharing. Now my question is, in case of no longer use will it leave behind no oily residue And is it confers water resistance??Petros wrote: ↑Wed Feb 22, 2012 9:35 pm Another method I have found works is to put it in by hand as far as possible (make sure the spline is engaged by rotating it back and fourth), than put a large screw driver or rod in the groove around the inner cv joint body (it should be at the edge closest to the diff housing) holding at about a 45 degree angle. Than drive with a hammer to push the spline shaft into the diff. When everything is lined up it should just pop into place.
There is a spring clip in the end of the spline shaft that has to be compressed so it slides into the diff, it sometimes helps to put some grease for ball joints on this clip and the splines (also grease up the seals). You just have to drive it in hard enough to get the clip to pop into its groove.
I have noticed that some brands of shaft do not have this groove, but that is not a very common type (DLB method above should work for those). Be careful you do not damage the boots doing this. IF in doubt wrap them with heavy duck tape when pounding on it, and remove when done. I just hate to hammer on the end of the axle, all the force is driven through both CV joints, and the risk of damaging the threaded end of the axle.
Good luck, you are almost done.
.
- Petros
- Highest Ranking Member
- Posts: 11933
- Joined: Sun Jan 28, 2007 6:31 pm
- My tercel:: '84 Tercel4wd w/extensive mods
- Location: Arlington WA USA
Re: Manual Transmission Removal and Re-Installation
Hi Ricky,
not sure what you are asking about with "in case of no longer use will it leave behind no oily residue And is it confers water resistance??"
could you elaborate? what is "it"? Please explain, I need more detail.
not sure what you are asking about with "in case of no longer use will it leave behind no oily residue And is it confers water resistance??"
could you elaborate? what is "it"? Please explain, I need more detail.
'87 Tercel 4wd SR5 (current engine swap project)
'84 Tercel 4wd (daily driver, with on going mods)
'92 Mazda MPV 4wd (wife's daily driver)
'85 Tercel 4wd DLX auto(daughter's daily driver)
'01 Honda Civic (other daughter's daily driver)
'84 Tercel 4wd (daily driver, with on going mods)
'92 Mazda MPV 4wd (wife's daily driver)
'85 Tercel 4wd DLX auto(daughter's daily driver)
'01 Honda Civic (other daughter's daily driver)
- dlb
- Highest Ranking Member
- Posts: 7330
- Joined: Mon Jul 06, 2009 9:03 pm
- My tercel:: '87 sr5, '83 dlx parts car
- Location: bc, canada
Re: Manual Transmission Removal and Re-Installation
Is ricky2marin a low-grade spammer? Of their two posts, each one has a link to something. It's not the usual gibberish we see in spam here but it is very suspicious.
I vote to ban ricky2marin.
I vote to ban ricky2marin.
Re: Manual Transmission Removal and Re-Installation
Peculiar for sure, I will send them an email requesting a reply. If none is received in a few days, we can ban the username.
Chris
Chris
Psalm 37:4 "Delight yourself in the Lord and he will give you the desires of your heart"
In remembrance of my friend ARCHINSTL:
T4WD augury?
"Oh, do not ask, 'What is it?' Let us go and make our visit."
T.S. Eliot - "The Love Song of J. Alfred Prufrock"
"Now and then we had a hope that, if we lived and were good, God would permit us to be pirates."
Mark Twain
In remembrance of my friend ARCHINSTL:
T4WD augury?
"Oh, do not ask, 'What is it?' Let us go and make our visit."
T.S. Eliot - "The Love Song of J. Alfred Prufrock"
"Now and then we had a hope that, if we lived and were good, God would permit us to be pirates."
Mark Twain